Opener BlackFly

The Opener BlackFly is an American electric-powered VTOL personal air vehicle designed by Canadian Marcus Leng and under development by his company, Opener, Inc of Palo Alto, California. It was publicly introduced on 12 July 2018, after nine years of development. The aircraft is intended to be supplied complete and ready-to-fly.[1]

BlackFly
Role Personal air vehicle
National origin United States
Manufacturer Opener Inc
Designer Marcus Leng
First flight October 2017 (Pre-production model)
Status Under development (2018)

The manufacturer claims that the design is the world's first ultralight fixed-wing, all-electric, vertical take-off and landing aircraft.[1] Investors in the company include Google co-founder Larry Page.[2][3]

Development

The first proof-of-concept version was flown on 5 October 2011, in Warkworth, Ontario, Canada, by Leng. He flew the next model, named the BlackFly, in August 2014 and then relocated the company to Palo Alto, California in September 2014. In February 2016, the second BlackFly prototype was first flown. By September 2017, the prototype had flown 10,000 mi (16,093 km) in a series of flights of at least 30 mi (48 km) each. The first pre-production aircraft was flown in October 2017.[1][4]

The design is intended for the FAR 103 Ultralight Vehicles category in the US and the Basic Ultralight Aeroplane category in Canada. The US version and international versions will have different ranges, speeds and weights to comply with national regulations.[1][5]

In discussing the design in person with Leng at AirVenture in July 2018, AVweb reviewer Paul Bertorelli indicated that it is "a terrific idea and I’m betting the concept itself has legs, whether Opener’s version fails to gain a market or not", but expressed concern about the lack of pricing and "cost/value relationship" marketing overreach. However he did indicate that "It’s early in their game and they have a long developmental road ahead before selling these things." Bertorelli also expressed concern that the company did not allow journalists access to look over the aircraft and would not answer any technical questions.[6]

The new CEO of Opener, Ben Diachun stated in January 2020 that the BlackFly was close to being ready for manufacturing and sales.[7]

Design

The aircraft is made from carbon-fiber reinforced epoxy with all-electric battery-powered propulsion. It has two 13.6 ft (4.15 m) cantilevered tandem wings, on the front and rear of a short fuselage. The fuselage has a single-seat cockpit under a bubble canopy. The forward wing is low, and the rear wing high, giving the cockpit good forward visibility. Each wing has four tractor configuration contrarotating propellers powered by electric motors. The tractor configuration prevents the flexible propellers from contacting the airframe. Each wingtip has winglets to improve lateral stability and reduce vortex drag. The aircraft weighs 313 lb (142 kg) empty and can carry a pilot and baggage totaling 250 lb (113 kg). It can accommodate a pilot of up to 6.5 ft (1.98 m) in height. A ballistic parachute is optional.[1][5][8]

The aircraft is not a tiltwing or tiltrotor design, instead, the entire aircraft changes pitch. When the aircraft is parked, both wings and their motors are canted up at about 45 degrees. To ascend vertically, the aircraft pitches up 45 degrees, so that the propellers pull vertically. The wing-mounted tractor propellers move air over the wings, reducing stall speeds. So, at pitch angles near zero degrees, the aircraft can fly slowly with high angles of attack. For efficient horizontal flight, the aircraft pitches down 45 degrees, canting the wings and propellors to an optimal angle of attack. The forward wing has a slightly lower angle of attack to aid stall recovery. At low speeds the forward wing will stall first, causing the nose to fall, increasing air speed and exiting a stall.[5][9]

The take-off and landing distances are 36 inches. The landing gear consists of a rub-strip on the bottom of an amphibious hull and a small rubber bumper on the rear of the fuselage. The lower edge of the winglets are skids that limit the vehicle's roll when parked. The vehicle is designed to fly from a grass surface, but can also be flown from fresh water, asphalt, snow and ice.[5]

Pilot controls are a joystick with a thumb control for altitude. Flight controls are triple-redundant fly-by-wire controlling the motors and dual elevons on the outer edge of both wings. Differential motor speeds provide control authority in pitch, roll and yaw. Elevons also permit control in an efficient unpowered glide mode. The elevons are in the prop-wash of the outer propellers, enhancing their roll and pitch authority at low speeds. Flight stability is software-controlled, with modes for cruise-control, "return-home," auto-land and geo-fencing.[5]

Most flight testing was unmanned, operated by software with a test weight in place of a pilot. Each motor weighs 4 lb (2 kg) and produces 130 lb (59 kg) of thrust. There are two batteries per motor, located in the wing, behind each motor. Adjacent batteries can be cross-connected for redundancy. The batteries are software-monitored.[5]

Specifications (BlackFly International)

Data from O'Connor and manufacturer.[1][5]

General characteristics

  • Crew: one
  • Length: 13 ft 5 in (4.09 m)
  • Wingspan: 13 ft 7 in (4.14 m)
  • Height: 5 ft (1.5 m)
  • Empty weight: 313 lb (142 kg)
  • Gross weight: 563 lb (255 kg)
  • Fuel capacity: 12KWh
  • Powerplant: 8 × 112 lb thrust/engine electric motors, 42.0 hp (31.3 kW) each
  • Propellers: 2-bladed, 3 ft (0.91 m) diameter composite, high aspect ratio

Performance

  • Cruise speed: 80 mph (130 km/h, 70 kn)
  • Range: 40 mi (64 km, 35 nmi) plus reserves
  • Rate of climb: 1,000 ft/min (5.1 m/s)

Avionics

See also

References
  1. O'Connor, Kate (12 July 2018). "Opener Reveals Ultralight eVTOL". AVweb. Retrieved 13 July 2018.
  2. "Google's Larry Page out to corner market in flying cars". The Times. Retrieved 25 July 2018.
  3. "Larry Page invests in another flying car startup". CNNMoney. Retrieved 25 July 2018.
  4. Opener, Inc (2018). "About Us". opener.aero. Retrieved 13 July 2018.
  5. Opener, Inc (2018). "Technology". opener.aero. Retrieved 13 July 2018.
  6. Bertorelli, Paul (25 July 2018). "AirVenture: Big Numbers In The Spreadsheet". AVweb. Retrieved 15 July 2018.
  7. "Exclusive: New CEO of Larry Page-backed 'flying car' startup says they may arrive this year". www.bizjournals.com. Retrieved 23 January 2021.
  8. Anglisano, Ashley (25 July 2018). "BlackFly Multirotor Makes AirVenture Debut". AVweb. Retrieved 25 July 2018.
  9. "Opener - About Us". Opener.aero. Opener Aerospace. Retrieved 27 July 2018.
This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.